 |
|
| If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
|
|
| If you can't view the Datasheet, Please click here to try to view without PDF Reader . |
|
|
| Datasheet File OCR Text: |
| H HiTRON ON-BOARD DC-DC CONVERTER HALF-BRICK BASE PLATE POWER MODULES INDUSTRIAL GRADE 165-200 WATTS SINGLE & DUAL OUTPUT HDH165-24B OR 48B-S & D SERIES FEATURES: SINGLE OUTPUT WIDE 2:1 INPUT RANGE 1500VDC ISOLATION STANDARD HALF-BRICK PACKAGE HIGH-EFFICIENCY POWER MODULE UNDER-VOLTAGE LOCKOUT DESIGNED TO MEET INTERNATIONAL SAFETY STANDARDS SPECIFICATION INPUT SPECIFICATION Input Range: Wide 2:1 Input DC Range 36-72Vdc or 18-36 Vdc. Input Voltage: Nominal 48Vdc or 24Vdc. Input Current: Typical 7.84A full load and 0.2A no-load @ 24Vdc nominal input. Typ.3.92A full load and 0.1A no-load @ 48Vdc nominal input. Input Fuse: Use external fuse. Soft-Start: Installed. Inrush Current: 4A @ 48Vdc. 8A @ 24Vdc. Input Filter: Pi-Network for EMI suppression. Under-Voltage Protection (UVP): Lock-out activated at 34-35.5Vdc input @48Vdc nominal input. 17.5-17.8Vdc input @24Vdc nominal input. Input OVP: 74-76Vdc @48Vdc nominal input. 37-38Vdc @24Vdc nominal. Input Reflected Ripple Current: 20mA pk-pk @48 Vdc. Isolation Voltage: 1,500Vdc input-output. Remote On/Off: TTL/CMOS-Compatible input control. Positive Logic version for Standard set up: ON(Enable)=Open(or 2.5-5.0Vdc above-Vin) OFF(Disable)=Short(or 0-0.8Vdc above-Vin) Negative Logic version option available by adding a "N" suffix to the end of Model #. Remark: Voltage refer to -Input (-Vin). OUTPUT SPECIFICATION Output Voltage: See Ratings Chart. Output Current: See Ratings Chart. Output Wattage: 165-200Watt continuous typical. Line Regulation: Various with input & output voltages. 0.1% typical. Load Regulation: Various with output voltages. 0.5% typical. Noise & Ripple: 1% rms typical. OVP: Built-in (latch). Adjustability: Maybe externally trimmed with fixed resistor or trim pot. Overload Protection (OLP): Fully protected against overload and short circuit. OLP set at typical 130% rating output wattage load. Consult the factory for special OLP setting. Operating Temperature: -40 to +100C (base plate). Power derating details please refer to the Derating Chart. Storage Temperature: -55 to +125 C. Temperature Coefficient: 0.02%/C. Humidity: Up to 95% RH, Non-Condensing. Cooling: At least 100LFM moving air is recommended for full load > +10C in a confined area. Air flow vs. power desrating details please refer to the Derating Chart. Industrial Grade. GENERAL SPECIFICATION Efficiency: 87.5-89% typical, various with input & output. Switching Frequency: Fixed frequency 330K Hz. Circuit Topology: 330K Hz. Forward Circuit. Transient Response: Peak transient <220mV and recovers Within 1mS after 25% load-change. Safety Standard: IEC60950 Class I. Case: Aluminum base plate with metal standoffs. Power Density: 60 Watts / Cubic inch typical. NOTE: (1) All measurements are at nominal input, full load, and +25C unless otherwise spec. (2) Line Regulation measured from High to Low Lines at full load. (3) Load Regulation measured from Full-Load (F-L) to Half-Load(H-L)at nominal input. (4) Correct fuse size by calculating the max. DC current drain at low Line input & adding 20-25% for desired fuse size. Due to requests in market and advances in technology, specifications subject to change without notice. -39- INPUT/OUTPUT & VOLTAGE/CURRENT RATINGS CHART SINGLE OUTPUT MODEL NO. HDH165-24B-S018600 HDH165-24B-S025600 HDH165-24B-S033500 HDH165-24B-S050450 HDH165-48B-S018600 HDH165-48B-S025600 HDH165-48B-S033500 HDH165-48B-S050450 INPUT Vdc Range Nominal 18-36Vdc 24Vdc 18-36Vdc 24Vdc 18-36Vdc 24Vdc 18-36Vdc 24Vdc 36-72Vdc 48Vdc 36-72Vdc 48Vdc 36-72Vdc 48Vdc 36-72Vdc 48Vdc OUTPUT VO1 # TYP. VOLT. MAX. PEAK 60A 1.8Vdc 62A 64A 60A 2.5Vdc 62A 64A 50A 3.3Vdc 52A 53A 45A 5.0Vdc 47A 48A 60A 1.8Vdc 62A 64A 60A 2.5Vdc 62A 64A 50A 3.3Vdc 52A 53A 45A 5.0Vdc 47A 48A DUAL OUTPUT MODEL NO. HDH165-24B-D025B HDH165-24B-D033B HDH165-24B-D033C HDH165-24B-D050C HDH165-24B-D050D HDH165-48B-D025B HDH165-48B-D033B HDH165-48B-D033C HDH165-48B-D050C HDH165-48B-D050D INPUT Vdc Range Nominal 18-36Vdc 18-36Vdc 18-36Vdc 18-36Vdc 18-36Vdc 36-72Vdc 36-72Vdc 36-72Vdc 36-72Vdc 36-72Vdc 24Vdc 24Vdc 24Vdc 24Vdc 24Vdc 48Vdc 48Vdc 48Vdc 48Vdc 48Vdc OUTPUT VO1 @ MIN. TYP. VOLT. MAX. 0A 0A 0A 0A 0A 0A 0A 0A 0A 0A 25A 22A 22A 20A 20A 25A 22A 22A 20A 20A 2.5Vdc 3.3Vdc 3.3Vdc 5.0Vdc 5.0Vdc 2.5Vdc 3.3Vdc 3.3Vdc 5.0Vdc 5.0Vdc 27A 25A 25A 22A 22A 27A 25A 25A 22A 22A OUTPUT VO2 @ MIN. TYP. VOLT. MAX. 0A 0A 0A 0A 0A 0A 0A 0A 0A 0A 25A 25A 25A 25A 22A 25A 25A 25A 25A 22A 1.8Vdc 1.8Vdc 2.5Vdc 2.5Vdc 3.3Vdc 1.8Vdc 1.8Vdc 2.5Vdc 2.5Vdc 3.3Vdc 27A 27A 27A 27A 25A 27A 27A 27A 27A 25A Symbols: "" OVP built-in. "#" Remote sensing. "@" Adjustable. Remarks: Peak output, less than 60Sec. With duty cycle <10%. "" Synchronous Rectifier. MECHANICAL DIMENSIONS: MM [INCHES] WEIGHT: 73.0g (2.6 Oz.) SINGLE O/P DUAL O/P PIN ASSIGNMENT PIN NO. SINGLE +Vin PIN# 1. REMOTE PIN# 2. ON/OFF CASE PIN# 3. -Vin PIN# 4. PIN# 5. DC COM. PIN# 6. -SENSE PIN# 7. VO1 ADJ. PIN# 8. +SENSE VO1 PIN# 9. ------PIN# 10. DUAL +Vin REMOTE ON/OFF CASE -Vin VO2 DC COM VO2 ADJ. VO1 DC COM VO1 ADJ. DERATING CHART -40- |
Price & Availability of HDH165-24B
 |
|
|
|
|
All Rights Reserved © IC-ON-LINE 2003 - 2022 |
| [Add Bookmark] [Contact Us] [Link exchange] [Privacy policy] |
|
Mirror Sites : [www.datasheet.hk]
[www.maxim4u.com] [www.ic-on-line.cn]
[www.ic-on-line.com] [www.ic-on-line.net]
[www.alldatasheet.com.cn]
[www.gdcy.com]
[www.gdcy.net] |